Home

2014 Ford Explorer exhaust manifold leak

Ford Explorer Lawsuit Alleges Vehicles Suffer Exhaust Leak Problem. September 19, 2014 Last Updated on December 6, 2018 . Important Information. The Ford exhaust settlement deadline has now passed. According to the settlement site, most claims needed to be submitted by February 25, 2019. The exceptions are claims made within two months after. NHTSA has broadened a probe into reports that 2011-2017 model year Ford Explorers are experiencing leaks in their exhaust systems, which could cause carbon monoxide to enter the vehicle's cabin P0430 piped up on this explorer, the car is one piece with the manifold, so replaced that, bolts, gaskets, oxygen sensor down stream. Problem was fixed, 1000..

Shop for New Auto Parts at 1AAuto.com http://1aau.to/c/32/b/exhaust-manifold1A Auto shows you how to repair, install, fix, change or replace a cracked, leaki.. 2004 Ford Explorer 120,000 mi, Visitor. I have read about too many nightmares about snapped off bolts and what it cost. Depending on how many bolts have snapped off, approximately $1,700 to $3,500. So I just put epoxy on the exhaust manifolds every time I change the oil. Report

How it's done: Determine if the manifold is cracked or broken. Remove and replace faulty exhaust manifold. Inspect exhaust studs, clean carbon and old gasket off cylinder head. Install new gasket and exhaust manifold. Start engine and check for exhaust leaks After having my 2013 to the dealership 4 times and them completing a TSB which cost me $550.00, and the manifold gasket replaced we are still left with a hor.. The parts and tools listed below are what is needed to complete the repair: (check fitment guide)Mopar Rust Penetrant I use-http://www.amazon.com/gp/product/.. Ford finally put out a Bulletin on the exhaust noises. I had it performed, it did nothing. It was simply two clamps. I took the vehicle back and as we knew, the root cause is the flex pipe and mesh covers below the driver and passenger seats. Ford says they have no fix and would do nothing further

Ford Explorer leaking exhaust? 04:18 The Ford Explorer is the best-selling midsize SUV in the country, with around one million on the road. But hundreds of customers say the vehicles might be. In Montgomery County, Maryland, where crews are inspecting all 108 of the county's Explorers, they're finding Explorer after Explorer with cracked exhaust manifolds, the part that carries exhaust. Dizziness, nausea and vomiting - these are just some of the symptoms experienced by Ford Explorer drivers. Yet, Ford has refused to issue a safety recall. The National Highway Traffic Safety is investigating the problem, which involves exhaust fumes entering the cabin of 2011-2017 Explorer models causing dangerous levels of carbon monoxide

Ford Explorer Lawsuit Exhaust Leak Problem ClassAction

  1. Ford Explorer 2014, Exhaust Manifold Gasket Set by Fel-Pro®. If you need durable gaskets to prevent leaks on your vehicle, Fel-Pro is the way to go. Engineered using the latest technologies and global engineering resources, the gaskets..
  2. Center for Auto Safety says Ford should recall 1.3 million Ford Explorers over exhaust leaks. July 4, 2018 — A Ford Explorer exhaust leak recall should be ordered for 2011-2017 SUVs to prevent.
  3. ary approval for a class action settlement, resolving allegations that certain Ford Explorer vehicles allowed carbon monoxide to leak into the.
  4. Tl the contact owns a 2014 Ford Explorer. The contact took the vehicle to rowe Ford auburn (699 center st, auburn, me 04210) for routine maintenance and was informed that the exhaust manifold was leaking and needed to be replaced. The manufacturer was notified of the failure. The vehicle was not repaired. The approximate failure mileage was.

Ford offers Explorer exhaust-leak fix. Washington — Ford Motor Co. is offering a fix for potential carbon monoxide leaks in 1.3 million of its Explorer SUVs in the U.S, although it maintains. Ford in October offered a no-cost service to North American owners of more than 1.4 million Explorers to make repairs and inspections to lessen the risk of exhaust-fume leaks. At the time, it said. The National Highway Traffic Safety Administration is expanding a probe into 1.33 million Ford Explorers from the 2011-17 model years over mounting reports of exhaust odors inside the cabin.The.

In 2016, Ford agreed to settle a U.S. class-action lawsuit involving 1 million 2011-2015 Explorer SUVs over exhaust odor complaints, including reimbursements of up to $500 for repairs and the. The average cost for a Ford Explorer exhaust manifold replacement is between $605 and $646. Labor costs are estimated between $158 and $199 while parts are priced at $447. This range does not include taxes and fees, and does not factor in your specific model year or unique location. Related repairs may also be needed 2014 Ford Explorer 4dr SUV. turbocharged 365hp 3.5L V6 6-speed shiftable automatic AWD. drivers side exhaust manifold studs broken (2). loud ticking/putt putt sound during cold start : Intake manifold was leaking coolant at the thermostat housing, needed to be replaced CEL was on, gas cap needed to be replaced.

Investigation Into Ford Explorer Exhaust Leaks - Consumer

1997 F150 4.6L Trition with 201,412 miles and counting!Decided that I was gonna do this job myself after getting some ridiculous quotes from a few shops. TH.. Dorman Direct Fit Exhaust Manifold with Integrated Federal Catalytic Converter 674-255. $. 402. 99. Part # 674-255. SKU # 296674. Year Warranty. Check if this fits your 2014 Ford Explorer. $ Smoke Under the Hood- If oil is leaking from the right spot, it can leak onto the exhaust manifold(s) and it gets smokey. It's not nearly as flammable as transmission fluid. All it usually does is smoke and stink. Oil Leak Causes: Ford Explorer. Fixing an oil leak means determining where it is coming from and repairing the issues

2005 Dodge Durango 5

How to fix P0430 on 2014 Ford Explorer V6 3

The exhaust manifold is engineered to steer harmful exhaust gases away from the cylinder head to the catalytic converter and exhaust system. Over time, an exhaust manifold becomes worn-out and cracked, causing the performance of your Explorer to plummet. It also puts other components within close proximity in danger of melting 2000 Ford F-150 93,000 mi, Visitor. Right side manifold leaking or cracked, took to shop, quote nearly $3,000. Not sure if I a going to fix it or junk it, would think Ford would do something about this issue when there have been so many complaints.Don't know if I will buy another Ford. Report

Your 2014 Ford Explorer exhaust system runs from the exhaust manifold (or header) flange connected to the engine, all the way to the exhaust tip at the rear. In between you will usually find a flex pipe, catalytic converter or two, a mid pipe, a resonator, a muffler, and several feet of carefully routed exhaust pipe tube Vehicle efficiency is increased by a Ford Explorer Exhaust Manifold, which speeds the exhausting of hazardous gases. Ford Explorer Exhaust Manifold - Exhaust Manifolds - Dorman Catco Eastern Catalytic DIY Solutions Genuine ATP - 2000 2013 1998 1997 2011 2014 2001 2015 00 13 98 97 11 14 01 15 - PartsGeek.co NHTSA investigates 1.3 million Ford Explorers after finding exhaust manifolds crack and leak. July 27, 2017 — A NHTSA Ford Explorer exhaust manifold investigation has been upgraded and expanded.

Ford Explorer owners have reported 496 problems related to engine exhaust system (under the engine and engine cooling category). The most recently reported issues are listed below. Also please check out the statistics and reliability analysis of Ford Explorer based on all problems reported for the Explorer Oil on Exhaust. Another reason you may experience a burning smell coming from your Explorer is oil on the exhaust. This is almost always caused by oil leaking from the valve covers onto the exhaust manifold. If this is the case, take a look under the hood with the engine cold and off, you should be able to see evidence that the oil is leaking Ford has an specialty extraction tool for the job ($50/stud). The new studs are superior in strength. The new Ford manifolds are only around $85 and stud kit/gasket another $80. The rest is labor. I drove mine around leaking for years, until the wrapped manifold cracked

2020-11-09. Recall no. 20V692000. Ford Motor Company (Ford) is recalling certain 2014-2016 Explorer, 2014-2015 Taurus and 2014 Edge vehicles equipped with 2.0L or 2.3L engines and front wheel. ford explorer 2012-2015, ford taurus 2013-2015: some vehicles equipped with 2.0l gasoline turbocharged direct injection engines built before 10/05/2014 may have lack of power and malfunction.

More complaints are rolling in about exhaust leaks in the Ford Explorer causing fumes to leak into the SUV's passenger compartment and now, the National Highway Traffic Safety Administration is. 2014 Ford Explorer exhaust system problems with 60 complaints from Explorer owners. The worst complaints are exhaust fumes in cab, emissions control system leak, and exhaust system falling off of car 2014 Ford Explorer 3. 5 liter eco-boost >>oil lines leak at turbo , causing oil to leak down onto exhaust. Very bad smell !! there is already recalls for newer models but not the 2014. People are going to get hurt. Ford only stated to keep my receipts for reimbursement if there is ever a re-call?

Engine Exhaust System problem 2. Tl the contact owns a 2014 Ford Explorer. When the accelerator pedal was depressed, the odor of exhaust fumes was present inside the vehicle. The cause of the failure was not determined. The local dealer and manufacturer were not notified of the failure. The vehicle was not repaired Tl-the contact owns a 2014 Ford Explorer. The contact stated while driving at 75 mph the vehicle seized without warning. The low oil pressure warning light illuminated once the engine shut off. The contact stated he was able to drift over to the shoulder restarted the vehicle several times and the enginge would shut off again

How to Replace Exhaust Manifold 06-10 Ford Explorer 4

Update: A previous version of this story indicated that Ford believed that leaks in the exhaust manifold and catalytic converter were to blame for carbon monoxide leaks. This was incorrect. The. Ford offers free repairs as Explorer exhaust complaints grow. In a major update about our ongoing CBS News investigation into reports of carbon monoxide seeping into Ford Explorers, the automaker. ford explorer exhaust-leak. my 2014 ford explorer first exhibited a strong exhaust leak smells in the cabin about 18 months ago with approximately 18-20,000 miles. the smell was most noticeable after coming to a stop with the car at full operating temperature Ford F-150/F-250: How to Repair a Leaky Manifold. Get more life out of the muscle in your motor by addressing leaky manifolds. Loss of horsepower and torque due to leaky gaskets is no way to enjoy your Truck Advance Auto Parts has 23 different Exhaust Manifold & Header for your vehicle, ready for shipping or in-store pick up. The best part is, our Ford Explorer Exhaust Manifold & Header products start from as little as $49.99. When it comes to your Ford Explorer, you want parts and products from only trusted brands

Exhaust Manifolds Can Crack and Cause Leak : Ford Explorer

Ford Explorer Right Exhaust Manifold 4

Ford Explorer Exhaust Manifold Repair Cost

  1. Equip cars, trucks & SUVs with 2014 Ford Explorer Exhaust Manifold Gasket from AutoZone. Get Yours Today! We have the best products at the right price
  2. The average cost for a Ford Explorer exhaust manifold gasket replacement is between $183 and $225. Labor costs are estimated between $160 and $201 while parts are priced at $24. This range does not include taxes and fees, and does not factor in your specific model year or unique location. Related repairs may also be needed
  3. Advance Auto Parts has 42 different Exhaust Manifold Gasket for your vehicle, ready for shipping or in-store pick up. The best part is, our Ford Explorer Exhaust Manifold Gasket products start from as little as $5.04. When it comes to your Ford Explorer, you want parts and products from only trusted brands

2013 Ford Explorer exhaust manifold leaking

The Center for Auto Safety is again calling on Ford Motor Co. to recall 1.3 million Ford Explorer crossovers over an increasing number of complaints that they leak carbon monoxide Common reasons for this to happen: Leak in Exhaust Manifold: A leak in the exhaust manifold, which collects exhaust gases, can cause the engine to sputter or run unevenly. This condition can also cause the Check Engine light to trigger as well as present increased engine noise and poor performance from the engine The 3.5L Ford EcoBoost engine has been growing in popularity for the past ten years. Models of the Ford F-150, the top-selling truck in the United States for four decades, have been using the 3.5L EcoBoost since 2011 to provide power and improved fuel economy. In 2015, the Ford Transit van adopted the small but mighty motor Equip cars, trucks & SUVs with 2014 Ford Explorer Exhaust Flange Gasket from AutoZone. Get Yours Today! We have the best products at the right price

Ford Explorer 4.6L 3v: Passenger Exhaust Manifold ..

Ford Explorer 2014, Natural Stainless Steel Exhaust Manifold with Integrated Catalytic Converter by Dorman®. Color: Natural. Header Coating: Uncoated. More like a complete kit than a single part, many of the Exhaust Manifolds include gaskets and hardware for a complete installation Equip cars, trucks & SUVs with 2014 Ford Explorer Exhaust Crossover Pipe from AutoZone. Get Yours Today! We have the best products at the right price

Exhaust Noise Issues Explorer ST Foru

The CRP Gen1 F150 Ecoboost Manifolds are designed with a larger, thicker casting. If you are replacing your manifolds due to a leak, it makes a lot more sense to use these manifolds due to them being less prone to warping. High performance larger runners provide 45% more flow over stock with no restriction throughout the RPM range. Ready to. Order Exhaust Intermediate Pipe for your 2014 Ford Explorer and pick it up in store—make your purchase, find a store near you, and get directions. Your order may be eligible for Ship to Home, and shipping is free on all online orders of $35.00+. Check here for special coupons and promotions

New hardware helps fix exhaust leaks; Also available in the Exhaust Manifold Hardware Kit; 2011-2014 Ford F53, 2011-2014 Ford F-250 Super Duty,F-350 Super Duty, 2011-2013 Ford F-550 Super Duty, 2012 Ford F-450 Super Duty, 2007-2010 Ford Explorer,Explorer Sport Trac V6 V8, 2005-2008 Ford F-150, 2003-2004 Ford Expeditio We have 18 exhaust gasket products to choose from for your 2014 Ford Explorer, and our low-cost options range from $3.18 up to $11.73 Change Part / Brand Change Vehicle

Is your Ford Explorer leaking exhaust? - CBS New

We currently carry 4 Exhaust Manifold & Header products to choose from for your 2014 Ford Expedition, and our inventory prices range from as little as $78.99 up to $143.34. On top of low prices, Advance Auto Parts offers 2 different trusted brands of Exhaust Manifold & Header products for the 2014 Ford Expedition Total price: $151.81. Add all three to Cart Add all three to List. Buy the selected items together. This item: Dorman 03309 Exhaust Manifold Hardware Kit for Select Models $29.18. In Stock. Ships from and sold by Amazon.com. FREE Shipping. Details. Fel-Pro MS 97083 Exhaust Manifold Gasket Set $26.70 We have 8 exhaust clamp products to choose from for your 2014 Ford Explorer, and our low-cost options range from $3.18 up to $39.58 Change Part / Brand Change Vehicle

Ford may be closer to major Explorer recall amid possible

  1. Anonymous, PA (2016 Ford Explorer Sport 3.5-L V6 turbo) The entire system failed, compressor, clutch, belt, and refrigerant had to be replaced at 65K. The total bill was $1100. Dean S., NC (2016.
  2. Exhaust leak into the cab Ford can't fix it and it is still under warranty Anonymous, TX (2015 Ford Explorer Base 3.5-L V6
  3. We currently carry 7 Exhaust Manifold & Header products to choose from for your 2014 Ford F-150, and our inventory prices range from as little as $79.99 up to $125.61. On top of low prices, Advance Auto Parts offers 3 different trusted brands of Exhaust Manifold & Header products for the 2014 Ford F-150
  4. Change vehicle. Your 2014 Ford F550 Super Duty exhaust system runs from the exhaust manifold (or header) flange connected to the engine, all the way to the exhaust tip at the rear. In between you will usually find a flex pipe, catalytic converter or two, a mid pipe, a resonator, a muffler, and several feet of carefully routed exhaust pipe tube
  5. Advance Auto Parts has 9 different Exhaust Manifold & Header for your vehicle, ready for shipping or in-store pick up. The best part is, our Ford Expedition Exhaust Manifold & Header products start from as little as $77.07. When it comes to your Ford Expedition, you want parts and products from only trusted brands

Ford Explorer leaking exhaust fumes in cabi

  1. Investigations are ongoing into Ford's 2014 Explorers as reports continue to raise concerns over exhaust system leaks, which could cause carbon monoxide to enter the vehicle's cabin. A colorless, odorless, tasteless gas, carbon monoxide is often called the silent killer as these properties make the gas hard to detect
  2. Owners of fifth-generation Explorer SUVS are apparently complaining that exhaust leaks are causing carbon monoxide poisoning. Kyle Hyatt March 21, 2019 4:54 p.m. P
  3. My Ford Explorer has a cracked exhaust manifold and two studs are busted. The dealer wants $850 to start to fix and charge me another $45 for each of the 6 other studs/bolts if they should break off. I thought I could try to remove them myself and drill out the busted studs/bolts
  4. e has a small one. It's around the exhaust manifold heat shield. Apparently, one of the studs fell in there, so there is very small spot where some exhaust comes out around the exhaust manifold heat shield. It's not alot of smoke, and none of it will come out of the hood when I'm driving
  5. Leaky Exhaust Manifolds & Catalytic Converter Failure. The most common cause of failure in a catalytic converter in an older car is that it becomes so clogged that the exhaust gases can't get through it to the muffler and out of the car. If air can't get out the rear of the vehicle, it can't come in the front end, so the engine dies.
  6. ated lamp code due to ambient temperatur: 12/09/14: NHTSA ID: 10056462 TSB ID: TSB-14-0091 Ford/lincoln: near intake manifold, an odor of raw fuel type.

2014 Ford Explorer Replacement Exhaust Manifolds - CARiD

  1. Within your Ford Explorer, the plastic intake manifold can crack and cause a detrimental coolant leak. The 1997-2001 Ford Explorer especially has this issue, with a plastic intake manifold notorious for overheating. Even with normal and regular driving use, the coolant can leak from the front of the manifold, triggering the check engine light.
  2. Leaks in a manifold are often cracks in the metal, due to the intense temperatures of the engine. Cracks may start out as small as a hairline crack; which may be noticeable when the vehicle is first started. Once the manifold heats up quickly; the crack might self-seal as the metal of the manifold expands. Visual Crack On Exhaust Manifold
  3. 699.95. PMXU300PRO-08mm-125. Adaptable Exhaust Manifold Repair. Bullit (10mm-150) 699.95. PMXU300PRO-10mm-150. Adaptable Exhaust Manifold Repair. What People Are Saying. The Promaxx ford ecoboost 3.5L kit seriously shaved hours off the exhaust manifold replacementif you know auto repair, you know these tools are a no-brainer.
  4. The intake manifold gasket seals the intake manifold to the cylinder heads. It may leak and allow the coolant to enter the intake port, the crank case, or it can drip down the side of engine on the outside. Knowing what is causing the coolant to leak from your exhaust manifold can help save you time and money
  5. g from the engine that changes with engine RPM. This could be a leak at the exhaust manifold caused either by loose/broken exhaust studs or a cracked exhaust manifold
  6. d you it was raining out and my car started to make a loud screeching noise and idle. When I put it in park white smoke was co

Video: Ford Explorer Exhaust Leak Recall Needed: Safety Group

Step 1. Inspect the intake manifold where the runners, or tubes, attach to the engine. Using the flashlight, look for signs of coolant leaks. They show as wet spots or stains around the runners in minor cases. In severe cases of coolant leaks, parts of the manifold are wet with coolant, or puddles of coolant are present That manifold is a cat converter too ! $ cha ching $ Prove your leak first, maybe just a gasket. Nuts&Bolts-wise it should be no problem, ( unless there's a stud broken ) but shop around for parts. Ford shows a production date difference in part number & price for unleaded fuel u.s. vehicles ; Pre 10/02/01 # YL8Z-5G232-DA $ 811.1

For 2011-2016 Ford Explorer Exhaust Manifold Gasket Set

TSB Reference #ASI-45212. Description: FORD: SOME VEHICLES AND TRUCKS ARE EXPERIENCING A MALFUNCTION WITH THE HEATED STEERING WHEEL BECOMING INOPERATIVE AND ON DEMAND TEST FAILURE. MODEL 2014-15 FUSION, 2011-15 MKX, 2013-15 SUPER DUTY, EXPLORER, TAURUS, MKS, MKT, 2015 F-150, M 1 Answer. blue is oil white is coolant/head gasket black too rich fuel mixture Blue/Gray Smoke: Blue/gray exhaust smoke is an indication of oil burning in the combustion chamber. These are possible symptoms and causes: Valve Seals: Leaking valve seals will cause blue/gray exhaust smoke

Ford Explorer Class Action Settlement Reached Over Carbon

If you've found red fluid under your Ford Explorer, you probably have a transmission leak. A transmission leak is a big deal. If you let too much transmission fluid leak, the transmission will begin to slip, which can quickly cause long term damage.. Unlike oil, transmission fluid is flammable, and will flash if it hits the exhaust manifold A leaking exhaust manifold gasket can cause a burned exhaust valve, which can cause exhaust from the combustion chamber to flow the wrong way into the intake manifold. On smaller-displacement engines in front-wheel-drive cars and most engines in rear-wheel-drive cars, replacing a leaking exhaust manifold gasket is quite easy

Engine / Drivetrain Talk - 4.6 Exhaust manifold leaking. - Ok I need some help with my F150. I have a 98 F150 4x4 with the 4.6 engine. It has about 179000 miles on it. It is still a good truck and seems to run smooth still. I am having an issue with the passenger side exhaust manifold sealing to the head. About 5.. Buy Exhaust Manifold Header Gasket Replacement for Ford Expedition F150 F250 F350 Super Duty Explorer Mustang 4.6 5.4L 97-10: Header Gaskets - Amazon.com FREE DELIVERY possible on eligible purchase

Ford Motor Company (Ford) is recalling certain model year 2012-2015 Ford Focus, 2013-2015 Ford Escape and Ford C-MAX, 2015 Lincoln MKC and Ford Mustang, and 2014-2016 Ford Transit Connect vehicles 01/16/2014 - 05/30/2014 Affected: 75,364 Defect: Ford motor company (ford) is recalling certain model year 2014-2015 ford explorer vehicles manufactured january 17, 2014 to may 31, 2014. the affected vehicles may have improperly welded rear suspension toe links that may fracture. Consequence CAUSE 4: A dirty (contaminated) MAF sensor.. CAUSE 5: An exhaust leak right before the pre-catalytic converter oxygen sensors.. CAUSE 6: Bad pre-catalytic converter oxygen sensor.. Remember, the most important thing to consider (or keep in mind) when you're troubleshooting a P0171 or a P0174 trouble code is that whatever is causing it, is making the PCM think that too much unmetered air is. The exhaust manifolds on your Ford vehicle routs exhaust gases into the exhaust system. On the 5.4L model, one manifold is mounted to the left and right side of the engine. When cracked or damaged, manifolds have to be replaced to prevent harmful emissions from escaping into the atmosphere. Follow this guide to.

Manifold/header/muffler/tail Pipe Problems of the 2014

Ford offers Explorer exhaust-leak fix - The Detroit New

Ford urged to recall Explorers to fix dangerous exhaust leak

Buy a 2014 Ford Explorer Oil Cooler at discount prices. Choose top quality brands Dorman, Genuine, Hayden. 14 2014 Ford Explorer Oil Cooler - Engine Mechanical - Dorman, Genuine, Hayden - PartsGee Buy ECCPP Driver Left Side Exhaust Manifold Kit for 2000-2015 Ford E-350 Super Duty 2003-2014 Ford E-150 E-250 5.4L Driver Side: Manifolds - Amazon.com FREE DELIVERY possible on eligible purchase Change vehicle. Controlling engine and transmission temperatures in your 2014 Ford Explorer is a difficult job. While the radiator, cooling fan relay (or fan clutch), and cooling fan keep coolant from getting too hot, the thermostat makes sure the antifreeze doesn't get too cold. The area in between is the ideal operation range for your engine ECCPP Exhaust Manifold Gasket Kit Passenger Side Right RH Fit for 2005-2014 for Ford Expedition Lincoln Navigator 2005-2010 for Ford F-150 F-250/F-350 Super Duty Lobo 5.4L. 4.4 out of 5 stars. 69. Save 6%. $66.99

Heavy duty exhaust manifold vs efi exhaust manifolds98 Exp 4Head Gasket Repair: Head Gasket Repair 1995 Mustang V6Intake Manifold 4Exhaust manifold replacement 2004 Ford F150 5